Influence of Calsination Temperature on Zeolite Synthesis from Non-Hazardous Wastes and Its Application as an Adsorbent of Mn Metal Ion

Authors

  • Upita Septiani Departemen Kimia, Fakultas Matematika dan Ilmu Pengetahuan Alam, Universitas Andalas, Padang
  • Syukri Departemen Kimia, Fakultas Matematika dan Ilmu Pengetahuan Alam, Universitas Andalas, Padang
  • Mia Yeliandri Departemen Kimia, Fakultas Matematika dan Ilmu Pengetahuan Alam, Universitas Andalas, Padang
  • Safni Departemen Kimia, Fakultas Matematika dan Ilmu Pengetahuan Alam, Universitas Andalas, Padang
  • Zilfa Departemen Kimia, Fakultas Matematika dan Ilmu Pengetahuan Alam, Universitas Andalas, Padang

DOI:

https://doi.org/10.25077/jku.14.1.29-35.2025

Abstract

In this research, zeolite material was synthesized by hydrothermal method using non- hazardou waste of fly ash as the raw material at low crystallization temperatures of 70oC with seawater as solvent. The effect of calsination temperature on synthesis of zeolite was studied, and the ability of synthesized zeolite to adsorb Mn metal ion in aqueous solution was also investigated. The synthesized zeolite was characterized by Fourier Transform Infra-Red (FT-IR), X-ray Diffraction (XRD), Scanning Electron Microscopy (SEM-EDS), and Surface Area Analyzer (SAA). Based on the results of XRD, the type of zeolites produced from the synthesized zeolite are zeolite X and sodalite. The synthesized zeolite was then tested for the adsorption of Mn metal ion, using atomic absorption spectrophotometer (AAS) and it was found that the zeolite material synthesized calcined 550oC had the highest adsorption capacity compared to other synthesized zeolite materials, where the maximum adsorption was 192,31 mg/g.

References

ilva, A. M.; Cunha, E. C.; Silva, F. D. R.; Leao, V. A.: Treatment of High-Manganese Mine Water with Limestone and Sodium Carbonate. J Clean Prod 2012, 29-30, 11-19.

Tauanova, Z.; Tsakiridisb, P. E.; Mikhalovskyc, S. V.; Inglezakisa, V. J.: Synthetic Coal Fly Ash-Derived Zeolites Doped with Silver Nanoparticles for Mercury (II) Removal from Water. Journal of Environmental Management 2018, 224, 164-171.

Omri, A.; Benzina, M: Removal of Manganese (II) Ions from Aqueous Solutions by Adsorption on Activated Carbon Derived a New Precursor. Alex Eng J 2012, 51, 343-350.

Ltaief, O.; Siffert, S.; Fourmetin, S.; Benzina, M.: Synthesis of Faujasit Type Zeolite from Low Grade Tunisian Clay for The Removal of Heavy Metal from Aqueous Waste by Batch Process. Kinetic and Equilibrium Study 2015, 18, 1123-1133.

Belviso, C.; Cavalcante, F; Gennaro, S. D.; Lettino, A.; Palma, A.; Ragone, P.; Fiore, S.: Removal of Mn from Aqueous Solution using Fly Ash and its Hydrothermal Synthetic Zeolite. Journal of environmental management 2014, 137, 16-22.

Eskom (Electricity Supply Commission, South Africa): Annual Report. 2011. www.eskom.co.za. Diakses pada 17.55.

Belviso, C.; Cavalcante, F.; Lettino, A.; Fiore, S.: Effects of Ultrasonic Treatment on Zeolite Synthesized from Coal Fly Ash. Ultrason Sonochem 2011, 18, 661-668.

Kumara, D. C.; Wijayanti, W.; Widhiyanuriyawan: Pengaruh Penggunaan Katalis Zeolit terhadap Kinetic Rate Tar Hasil Pirolisis Serbuk Kayu Mahoni (Switenia Macrophylla). Jurnal Rekayasa Mesin 2015, 6, 19-25.

Wu, X.; Tong, F.; Young, X.; Zhou, J.; Zhang, L.; Jia, H.; Wei, P.: Effect of NaX Zeolite-Modified Graphite Felts on Hexavalent Chromium Removal in Biochatode Microbial Fuel Cells. Journal of Hazardous Materials 2016, 308, 303-311.

Lestari, D. Y.: Kajian Modifikasi dan Karakterisasi Zeolit Alam dari Berbagai Negara. Prosiding Seminar Nasional Kimia UNY 30 Oktober 2010.

Boycheva, S.; Zgureva, D.; Vassilev, V.: Kinetic and Thermodynamic Studies on The Thermal Behaviour of Fly Ash from Lignite Coals. Fuel 2013, 108, 639–646.

Fatiha, W. Y.; Septiani, U.; Arief, S.: Sintesis Zeolit dari Fly Ash Batubara Ombilin dengan Air Laut pada Temperatur Rendah. Skripsi FMIPA Universitas Andalas 2013.

Septiani, U.; Fatiha, W. Y.; Arief, S.: Sintesis dan Karakterisasi Zeolit Faujasit dari Limbah Batubara Ombilin dengan Metoda Alkali Hidrotermal Air Laut. J Ris Kim 2015, 8, 165-169.

Septiani, U.; Fajri; Andriany, R.: Aplikasi Zeolit NaX yang disintesis dari Abu Terbang PLTU Ombilin untuk Penyerapan Gas CO2. Jurnal Kimia Unand 2015, 4, 16-23.

Deni, F.; Fajar; Sulardjaka: Sintesis Zeolit A Berbahan Dasar Limbah Geotermal dengan Metode Hidrotermal. Simposium Nasional RAPI XI FT UMS 2012.

Tuschl, K.; Clayton, P. T.; Gospe, S. M.: Syndrome of Hepatic Cirrhosis, Dystonia, Polycythemia and Hypermanganesemia caused by Mutations in SLC30A10, a Manganese Transporter in Man. Am J Hum Genet 2012, 90, 457–66

Maghfiroh, L.; Mahatmanti, F. W.; Kusumastuti, E.: Adsorpsi Remazol Brilliant Blue Menggunakan Zeolit yang Disintesis dari Abu Layang Batubara. Indonesian Journal of Chemical Science 2017, 6, 43-49.

Dedi, A. Pengaruh pH dan Template pada Sintesis Zeolit NaX dari Fly Ash untuk digunakan sebagai Adsorben dalam Menanggulangi Limbah Amonia Rumah Sakit. Skripsi FMIPA Universitas Andalas 2016.

Murniati; Nutrul, H.; Mudasir: Pemanfaatan Limbah Abu Dasar Batubara sebagai Bahan Dasar Sintesis Zeolit dan Aplikasinya sebagai Adsorben Logam Berat Cu(II). Prosiding Seminar Nasional Penelitian Pendidikan dan Penerapan MIPA Yogyakarta 2009.

Belviso, C.; Cavalcante, F.; Fiore, S.: Synthesis of zeolite from Italian Coal Fly Ash: Differences in Crystallization Temperature using Seawater Instead of Distilled Water. Waste Management 2010, 30, 839 - 847.

Harry, M., Activated Carbon, Edisi Pertama, Elsevier, Great Britain, 2006.

Lapari, S.S.; Ramli, Z.; Triwahyono, S.: Effect of Different Templates on The Synthesis of Mesoporous Sodalite. Journal of Chemistry 2015, 1 - 6.

Priyadi: Adsorpsi Logam Berat Cu, Pb dan Cd pada Zeolit Sintetik ZSM-5 yang Disintetis dengan Suhu Rendah. Tesis Pascasarjana Institut Pertanian Bogor 2015.

Downloads

Published

2025-05-31

How to Cite

Septiani, U., Syukri, Mia Yeliandri, Safni, & Zilfa. (2025). Influence of Calsination Temperature on Zeolite Synthesis from Non-Hazardous Wastes and Its Application as an Adsorbent of Mn Metal Ion. Jurnal Kimia Unand, 14(1), 29–35. https://doi.org/10.25077/jku.14.1.29-35.2025

Issue

Vol. 14 No. 1 (2025): May 2025

Section

Articles

License

Copyright (c) 2025 Jurnal Kimia Unand

Creative Commons License

This work is licensed under a Creative Commons Attribution 4.0 International License.

Please find the rights and licenses in Jurnal Kimia Unand (J. Kim. Unand).  Authors who publish with J. Kim. Unand agrees to the following policies. No specific document sign-off is required.

1. License

The use of the article will be governed by the Creative Commons Attribution license as currently displayed on the Creative Commons Attribution 4.0 International License.

2. Author(s)' Warranties

The author warrants that the article is original, written by the stated author(s), has not been published before, contains no unlawful statements, does not infringe the rights of others, is subject to copyright that is vested exclusively in the author and free of any third party rights, and that any necessary written permissions to quote from other sources have been obtained by the author(s).

3. User Rights

Under the Creative Commons license, the journal permits users to copy, distribute, and display the material. Users will also need to attribute authors and J. Kim. Unand on distributing works in the journal and other media of publications.

4. Rights of Authors

Authors retain all their rights to the published works, such as (but not limited to) the following rights;

  • Copyright and other proprietary rights relating to the article, such as patent rights,
  • The right to use the substance of the article in own future works, including lectures and books,
  • The right to reproduce the article for own purposes,
  • The right to self-archive the article,
  • The right to enter into separate, additional contractual arrangements for the non-exclusive distribution of the article's published version (e.g., post it to an institutional repository or publish it in a book), with an acknowledgment of its initial publication in this journal.

5. Co-Authorship

Suppose more than one author jointly prepared the article. In that case, any author submitting the manuscript warrants that he/she has been authorized by all co-authors to be agreed on this copyright and license notice (agreement) on their behalf; and agrees to inform his/her co-authors of the terms of this policy. J. Kim. Unand will not be held liable for anything arising due to the author(s) internal dispute. J. Kim. Unand will only communicate with the corresponding author.

6. Royalties

By submitting the articles, the authors agreed that no fees are payable from J. Kim. Unand.

7. Privacy Statement 

The names and email addresses entered in this journal site will be used exclusively for the stated purposes of this journal and will not be made available for any other purpose or to any other party.

However, due to the advancement and availability of hacking and data mining techniques found over the Internet,  J. Kim. Unand cannot guarantee that other parties will not mine our users' email addresses in any possible ways found over the Internet.

8. Miscellaneous

J. Kim. Unand will publish the article (or have it published) in the journal if the article’s editorial process is completed and J. Kim. Unand has become obligated to have the article published. The author acknowledges that the article may be published so that it will be publicly accessible, and such access will be free of charge for the readers.